Road Base Stabilizer

Road Base Stabilization of paved roads will deliver either a lasting road or one that fails prematurely. Our Road Base Stabilizer, Terra Seal Xtream (TSX) , has proven many times over that the stronger the base the stronger the road. Terra Seal Xtream (TSX) is used as a road base stabilizer of any type of soil for which a wearing surface has been prescribed. This includes roadways, parking lots, airfield runways, and any other type of traffic area that will be covered with asphalt, chip-seal, or even concrete. When Terra Seal Xtream (TSX) is used properly, as a road base stabilizer, the road base strength will be significantly increased, and penetration by moisture will be greatly reduced thus delivering a road that will last much longer

Our product Terra Seal Xtream (TSX) sits on the leading edge of technology for products specifically designed with dust control, road dust control, soil stabilization, erosion control and soil permeability enhancement as the end objective.  For more information regarding Terra Seal Xtream (TSX) please visit our main product page.

Our Road Base Stabilizer Product Test Results

As depicted by the charts below, laboratory testing has revealed that the presence of Terra Seal Xtream (TSX) in a soil sample can increase the strength significantly. This test was with a soil that was initialy uncompactable. Product added at percent of soil weight

marshall test

Soil Stabilization testSoil stabilization testsoil stabilization

 

Densification Due To Low Quality Road Base Stabilizer

Problem areas with improper road base stabilization is a process known as densification. Densification is where the road base is not stabilized to the point of impeding further compression. Our road base stabilizer,Terra Seal Xtream (TSX) will prevent further compression of the base material thus elimination of deformation due to densification. Water intrusion into the base material will cause substantial road degradation when a low quality road base stabilizer is present. Once water has entered a road pavement, damage will ensue caused by hydraulic pressure,this pressure forces the water further into the road fabric and breaks it up. This process can be very rapid once it begins. Eventually the water will descend to the road base below the road pavement and weaken this layer. Once this begins a deep seated failure of the road will occur. When the low permeability characteristics of Terra Seal Xtream (TSX) are taken advantage of with regard to road base stabilization this problem can be controlled. See our Permeability Reduction page for more information

1-830-431-2209 or Email


1-830-431-2209 or Email

 For More Information on products and Dust Control Inc business opportunities, contact: EMAIL: DCI Services
Dust Control Inc., USA
� Phone: 1-830-431-2209 - �


1-830-431-2209 or Email - Copyright � 2008 - 2016 Dust-Control-Inc.Com All Rights Reserved